Please use this identifier to cite or link to this item: http://lib.kart.edu.ua/handle/123456789/5223
Title: Дорожні цементні бетони з високою міцністю на розтяг
Other Titles: Road cement concrete with high flexural strength
Authors: Захаров, Денис Сергійович
Zakharov, D. S.
Keywords: активна мінеральна добавка
дорожній бетон
лещадна частинка
міцність при згині
міцність при стиску
органо-мінеральний комплекс
поліпропіленова фібра
структура бетону
суперпластифікатор
active mineral additive
road concrete
flat particle
flexural strength
compressive strength
organo-mineral complex
polypropylene fiber
concrete structure
superplasticizer
Issue Date: 2019
Publisher: Харківський національний автомобільно-дорожній університет
Citation: Захаров Д. С. Дорожні цементні бетони з високою міцністю на розтяг : дис. ...канд. техн. наук : 05.23.05 – будівельні матеріали та вироби ; 19 – Архітектура і будівництво / Денис Сергійович Захаров ; наук. керівник Толмачов С. М. ; Харк. нац. автомоб.-дор. ун-т ; Укр. держ. ун-т залізн. траснп. - Харків, 2019. - 207 с. - Бібліогр. : с. 168-184.
Abstract: UA: Захаров Д.С. Дорожні цементні бетони з високою міцністю на розтяг. – Рукопис. Дисертація на здобуття наукового ступеня кандидата технічних наук за спеціальністю 05.23.05 – будівельні матеріали та вироби. – Український державний університет залізничного транспорту МОН України, Харків, 2019. Дисертація присвячена актуальній проблемі підвищенню міцності дорожніх цементобетонів на розтяг при згині за рахунок підвищення ефективності застосування його структурних компонентів. Для її вирішення на підставі аналізу літературних даних виділені основні компоненти бетону, що впливають на міцність бетонів при згині. У роботі отримали подальший розвиток теоретичні уявлення про вплив хімічних і активних мінеральних добавок та їх комплексів на процеси структуроу- творення в зоні контакту. Показано, що введення активної мінеральної добавки приводить до утворення більшої кількості низькоосновних гідросилікати кальцію переважно в зоні контакту та прилеглій зону, що доведено експериментально. Запропоновано і обґрунтовано механізм впливу лещадних частинок. Показа- но, що при віброущільненні лещадні частинки переміщаються в верхню частину бетону, при цьому під ними і в зоні контакту утворюється підвищена пористість. За допомогою оптико-мікроскопічних досліджень структури бетону запропоновано і обґрунтовано механізм впливу активної мінеральної добавки, який полягає в диспергуванні великих повітряних бульбашок і утворенні підвищеної кількості мікропор. Виконано відповідні розрахунки, що підтверджують це. Показано, що при введенні оптимальної кількості поліпропіленової фібри необхідних геометричних розмірів міцність дорожнього бетону при згині і його морозостійкість зростають. Проведені фізико-хімічні дослідження продуктів гідратації цементного каменю, що містить органо-мінеральний комплекс і активну мінеральну добавку. Проведено дослідно-промислове впровадження резуль- татів досліджень. Розроблено проект державного стандарту України, а також 4 галузевих нормативних документа. Розраховано економічний ефект від впровадження. EN: Zakharov D.S. Road cement concrete with high flexural strength. – Manuscript. Thesis for the degree of candidate of technical sciences by specialty 05.23.05 – building materials and products. – Ukrainian State University of Railway Transport, Ministry of Education and Science of Ukraine, Kharkiv, 2019. The thesis is devoted to the actual problem of increasing the flexural strength of road cement concrete by increasing the effectiveness of its structural components. For its solution, based on the analysis of literary data, the main components of the concrete are determined, which influence on the flexural strength of concrete. Theoretical understanding of the effect of chemical and active mineral additives and their complexes on the structure formation processes in the contact zone of cement stone-aggregate was further developed. It is shown that the introduction of an active mineral additive leads to the formation of a large amount of low-basic calcium hydrosilicates, mainly in the contact zone and the adjacent zone, which has been experimentally proved. The mechanism of the influence of the flat particles is proposed and substantiated. It has been shown that during vibrocompaction, flat particles move to the upper part of the concrete, and at the same time, increased porosity is formed under them and in the contact zone. With the aid of optical microscopic studies of the concrete structure, the mechanics of the action of an active mineral additive, which consists in the dispersion of large air bubbles and the formation of an increased number of micropores, is proposed and substantiated. Conducted calculations that confirm this. It is shown that with the introduction of the optimal amount of polypropylene fiber of the required geometric dimensions, the flexural strength of road concrete and its frost resistance increase. Physical and chemical studies of the hydration products of cement stone, which contains an organic-mineral complex and a mineral additive, have been carried out. Conducted pilot implementation of research results. A draft state standard of Ukraine, and 4 regulatory documents. The calculation of the economic effect was carried out.
URI: http://lib.kart.edu.ua/handle/123456789/5223
Appears in Collections:2019

Files in This Item:
File Description SizeFormat 
dis_Zakharov.pdf937.26 kBAdobe PDFView/Open


Items in DSpace are protected by copyright, with all rights reserved, unless otherwise indicated.